Jackpot

The fan in the brewing equipment is an important part of equipment accessories, so it is necessary for us to do a good job in daily maintenance. Now let's see how to do it.

酿酒设备风机的使用环境应始终保持清洁，风机表面应保持清洁，进风口和出风口不应有杂物。定期风机及管道内的灰尘等杂物。只能在风机全正挡的情况下操作。同时，要保持供电设施有足够的容量和稳定的电压。严禁无相位运行。

The use environment of the fan of wine making equipment should always be kept clean, the surface of the fan should be kept clean, and the air inlet and outlet should be free of debris. Regularly remove the dust and other debris in the fan and pipe. It can only be operated with the fan in full positive gear. At the same time, it is necessary to keep the power supply facilities with sufficient capacity and stable voltage. Operation without phase is strictly prohibited.

酿酒设备的供电线路必须是专用线路，不得使用临时线路长期供电。风机运行过程中发现风机有异响，电机发热严重，外壳带电，开关跳闸，无法启动等。所以立即停机检查。为确保，风机运行期间不允许进行维护。维修后，应进行五分钟左右的试运转，确认无异常现象后，方可启动机器。

The power supply line of wine making equipment must be special line, and temporary line shall not be used for long-term power supply. During the operation of the fan, it is found that the fan has abnormal noise, the motor is heated seriously, the shell is charged, the switch trips, and it cannot be started. So stop the machine immediately for inspection. In order to ensure safety, maintenance is not allowed during the operation of the fan. After maintenance, the machine can be started only after about five minutes of test run and no abnormal phenomenon is confirmed.

根据使用环境条件，不定期补充或更换酿酒风机设备轴承(电机封闭式轴承在使用寿命期间不需要更换)。为确保风机在运行过程中润滑良好，加油次数不得少于1000小时/次。封闭式轴承和电机轴承应填充ZL-3锂基润滑脂，并且应填充轴承内外圈的2/3。严禁无油操作。

According to the use of environmental conditions, the bearing of brewing fan equipment should be supplemented or replaced irregularly (the closed bearing of motor does not need to be replaced during the service life). In order to ensure good lubrication of the fan during operation, the number of oil filling shall not be less than 1000 hours / time. The enclosed bearing and motor bearing shall be filled with zl-3 lithium base grease and 2 / 3 of the inner and outer rings of the bearing. Oil free operation is strictly prohibited.

酿酒设备风机应储存在干燥的环境中，电机应防潮。风机露天存放时，应采取防雨措施。应防止风机在储存和运输过程中碰撞，以免损坏风机。

The fan of wine making equipment should be stored in a dry environment, and the motor should be moisture-proof. When the fan is stored in the open air, rain proof measures shall be taken. The collision of fans during storage and transportation shall be prevented to avoid damaging the fans.

酿酒设备风机的维护关系着设备在使用中是否能按照我们规划的情况进行工作，如果还有其它问题，欢迎继续关注http://www.scjiekai.com我们。

The maintenance of wine equipment fan is related to whether the equipment can work according to our plan. If there are other problems, please continue to pay attention http://www.scjiekai.com We are.